Hamilton Beach Gen 4 FlexBrew Single-Serve Coffee Maker Manual

Hamilton Beach Gen 4 FlexBrew Single-Serve Coffee Maker

IMPORTANT SAFEGUARDS

When using electrical appliances, basic safety precautions should always be followed to reduce the risk of fire, electric shock, and/or injury to persons, including the following:

Read all instructions.
This appliance is not intended for use by persons (including children) with reduced physical, sensory, or mental capabilities, or a lack of experience and knowledge, unless they are closely supervised and instructed concerning the use of the appliance by a person responsible for their safety.
Close supervision is necessary when any appliance is used by or near children. Cleaning and user maintenance shall not be done by children without supervision. Children should be supervised to ensure that they do not play with the appliance.
Do not touch hot surfaces. Use handles or knobs. Care must be taken, as burns can occur from touching hot parts or from spilled, hot liquid.
To protect against electric shock, do not place a cord, plug, or coffee maker in water or other liquid.
Unplug from the outlet when not in use and before cleaning. Allow to cool before putting on or taking off parts and before cleaning the appliance.
The coffee maker must be operated on a flat surface away from the edge of the counter to prevent accidental tipping.
The use of accessory attachments not recommended by the appliance manufacturer may cause injuries.
Do not operate any appliance with a damaged supply cord or plug, or after the appliance malfunctions or has been dropped or damaged in any manner. Supply cord replacement and repairs must be conducted by the manufacturer, its service agent, or similarly qualified persons in order to avoid a hazard. Contact Customer Service for information on examination, repair, or adjustment as set forth in the Limited Warranty.
Do not use outdoors.
Do not let the cord hang over the edge of the table or counter or touch hot surfaces, including the stove.
Do not place the coffee maker on or near a hot gas or electric burner or in a heated oven.
To disconnect the coffee maker, turn the brew cycle off and then remove the plug from the wall outlet. To unplug, grasp the plug and pull from the outlet. Never pull from the power cord.
Scalding may occur if the lid is removed during the heating cycle.
Do not use the appliance for other than intended use.
WARNING! To avoid hot water spraying from the piercing needle, do not lift the lid during the brewing process.
Do not place the coffee maker in a cabinet when in use.
CAUTION! Cut Hazard: The removable pod holder contains a sharp needle. Use caution when handling.
CAUTION! Cut Hazard: The piercing needle is sharp. Use caution when cleaning.
WARNING: Risk of Fire or Electric Shock. Do not remove the bottom cover. No user-serviceable parts inside. Repair should be done by authorized service personnel only.

SAVE THESE INSTRUCTIONS

Other Consumer Safety Information

This appliance is intended for household use only.

WARNING

Electrical Shock Hazard

This appliance is provided with a polarized plug (one wide blade) to reduce the risk of electric shock. The plug fits only one way into a polarized outlet. Do not defeat the safety purpose of the plug by modifying the plug in any way or by using an adapter. If the plug does not fit fully into the outlet, reverse the plug. If it still does not fit, have an electrician replace the outlet.

The length of the cord used on this appliance was selected to reduce the hazards of becoming tangled in or tripping over a longer cord. If a longer cord is necessary, an approved extension cord may be used. The electrical rating of the extension cord must be equal to or greater than the rating of the appliance. Care must be taken to arrange the extension cord so that it will not drape over the countertop or tabletop where it can be pulled on by children or accidentally tripped over.

To avoid an electrical circuit overload, do not use another high-wattage appliance on the same circuit with this appliance.

Parts and Features

Before first use: Wash all removable parts in hot, soapy water. Rinse and dry. Brew one cycle with water and discard the water.

Removable Pod Holder with Handle
Removable Brew Basket for Ground Coffee with Hinged Lid and Handle
Lid
Removable Needle Holder with Black Seal
Black Seal
Piercing Needle
Funnel
Removable Cup Rest/Storage Container
Control Panel
Removable 50 oz. (1.48 L) Water Reservoir with Removable Lid
Lid Latch
(8 oz./237 mL) Button
(10 oz./296 mL) Button
(12 oz./355 mL) Button
(14 oz./414 mL) Button
(iced coffee) Button
Refill Water Light

How to Brew Iced Coffee

WARNING: Burn Hazard.

If overflow occurs, unplug and allow the coffee maker to cool.

To avoid hot coffee overflowing:

Fully insert cup or travel mug on cup rest.
Do not lift the lid during the brewing process.
Use an appropriately sized cup or travel mug for your brew size.
If the brew cycle is stopped early, the coffee must be drained. Return the cup or travel mug to the cup rest. Press the desired cup size button. Discard coffee. Failure to drain the cup or travel mug can cause the next cup brewed to overflow.

CAUTION: Cut Hazard.

The removable pod holder has a sharp needle. The piercing needle on the underside of the lid is also sharp. Use caution when handling.

NOTES:

If the Lid is opened or any button is pressed to end the brew cycle early, discard the contents of the cup or travel mug and pod. Press the desired cup size button to restart the brewing cycle.
Use only cold water in the Reservoir. Do not use hot water.
Do not reheat coffee in the machine.
Do not use creamer or nondairy creamer in the Reservoir.
Do not use hot cocoa powder or mix in a Removable Brew Basket.
If finely ground coffee is used, coffee may continue to drip after the light has gone off.
If the brew indicator lights flash three times, the Lid is not closed. Lower Lid until it clicks to lock. Press the (iced coffee) button.
Do not brew coffee without the Removable Brew Basket in place.
If you have sediment from coffee, add a #1 paper cone coffee filter to the Removable Brew Basket.
Do not brew coffee before ensuring the Removable Needle Holder arrow icon (▲) is aligned with the lock icon inside the FlexBrew Lid.

Lift the Water Reservoir and remove the Lid. Add water to at least the MIN fill line (16 oz. [473 mL]) or the MAX fill line (50 oz. [1.48 L]). Replace the Lid and return the Water Reservoir to its place.
Plug into an outlet.
Lift the Lid Latch until the Lid stays in place.
Open the Brew Basket Lid; then place the Removable Brew Basket on the countertop.
a. Add ground coffee to Removable Brew Basket: Add a maximum of 3 tablespoons (15 g) of ground coffee to the Removable Brew Basket. Do not fill above the MAX fill line. Close Brew Basket Lid. Place the Brew Basket in the Funnel.
OR
5. b. Place the Removable Pod Holder in the Funnel. Place the Ace Pod into the Pod Holder. Do not remove the foil.
Close the Lid and snap it in place to latch the Lid closed.
Add ice to a 16-oz. heatproof tumbler/ travel mug and place it on the cradle with the Storage Container removed. DO NOT use a glass.
Press (iced coffee) button. (iced coffee) The button will illuminate when the coffee is brewing.
Coffee Maker will shut off automatically when brewing is complete.
Unplug.
The removable Brew Basket should be rinsed after every use.
NOTE: If the Refill Water Light and selected cup size light are flashing, refill the Water Reservoir, then press the flashing cup size button to finish brewing.

How to Brew a Hot Coffee Pod

If overflow occurs, unplug and allow the coffee maker to cool.

To avoid hot coffee overflowing:

Fully insert cup or travel mug on cup rest.
Do not lift the lid during the brewing process.
Use an appropriately sized cup or travel mug for your brew size.
If the brew cycle is stopped early, the coffee must be drained. Return the cup or travel mug to the cup rest. Press the desired cup size button. Failure to drain the cup or travel mug can cause the next cup brewed to overflow. Discard coffee.

CAUTION: Cut Hazard.

The removable pod holder has a sharp needle. The piercing needle on the underside of the lid is also sharp. Use caution when handling.

NOTES:

If the Lid is opened or any button is pressed to end the brew cycle early, discard the contents of the cup or travel mug and pod. Press the desired cup size button to restart the brewing cycle.
Use only cold water in the Reservoir. Do not use hot water.
Do not reheat coffee in the machine.
Do not use creamer or nondairy creamer in the Reservoir.
After brewing pods, such as hot cocoa, sugar-based, or keto, immediately brew a water-only cycle without a pod to avoid the possibility of clogging the piercing Needle.
Press any cup-size button to stop the brew cycle.
All cup-size buttons flash 3 times: The Coffee Maker Lid is not closed properly. Push the Lid down to lock it into place. Press the desired cup size button.
Do not brew coffee before ensuring the Removable Needle Holder arrow icon (▲) is aligned with the lock icon inside the FlexBrew Lid.

Lift the Water Reservoir and remove Lid. Add water to at least the MIN fill line (16 oz. [473 mL]) or the MAX fill line (50 oz. [1.48 L]). Replace the Lid and return the Water Reservoir to its place.
Plug Ian into the outlet.
Lthe the ift Lid Latch unthe the til Lid stays in place.
Plthe the ace Removable Pod Holder in Funnel.
Place a pod into Pod Holder. Do not remove the file.
Close Lidit it and snap it in place to the race pod.
Use Cup Rest for a cup/or remove Cup Rest for a travel mug.
Press desired cup size button: (8 oz./237 mL) or (10 oz./ 29The desired cup size button will illuminate when coffee is brewing.
Coffee Maker will shut off automatically when brewing is The pod plug.
Pod Holder should be rinsed after every use.
NOTE: If the Refill Water Light and selected cup size light are flathe the shing, refill the Water Reservoir, then press the last cup size button to finish brewing.

How to Brew Hot Ground Coffee

WARNING Burn Hazard.

If overflow occurs, unplug the coffee maker and allow the coffee maker to cool.

To avoid hot coffee overflowing:

Fully insert cup or travel mug on cup rest.
To avoid overflow, keep the ground coffee below the MAX fill line.
Do nothe the t lift the lid during the brewing process.
If the brew cycle is stopped early, the coffee must be drained. The Return cup or tram. hethene tup resttopress the desired cup size button. Failure to drain the cup or travel mug can cause the next cup brewed to overflow. Discard coffee.

CAUTION Cut Hazard.

The piercing needle on the underside of the lid is sharp. Use caution when handling.

NOTES:

If the Lid is opened or any button is pressed to end the brew cycle early, discard the contents of the cup or travel mug and pod. Press the desired cup size button to restart the brewing cycle.
Use only cold water in the Reservoir. Do not use hot water.
Do not reheat coffee in the machine.
Do not use creamer or nondairy creamer in the Reservoir.
Do not use hot cocoa powder or mix in Brew Basket.
If finer ground coffee is used, coffee may continue to drip after the timer light has gone off.
Press the desired cup size button again to stop brewing mid-cycle.
If the brew indicator lights flash three times, the Lid is not closed. Lower Lid until it clicks to lock. Press the desired cup size button.
Do not brew coffee without a Removable Brew Basket in place.
If you have sediment from coffee, add a #1 paper cone coffee filter to the Removable Brew Basket.
Do not brew coffee before ensuring the Removable Needle Holder arrow icon (▲) is aligned with the lock icon in the side FlexBrew Lid.

Lift the Water Reservoir and remove the Lid. Add water to at least the MIN fill line (16 oz. [473 mL]) or MAX fill line (50 oz. [1.48 L]). Replace the Lid and return the Water Reservoir to its place.
Plug into an outlet.
Lift the Lid Latch unthe til the Lid stays in place.
Other than the pen, Brew Basket Lid, place the Removable Brew Basket on the countertop.
Add ground coffee to Removable Brew Basket: Add a maximum of 3 tablespoons (15 g) of ground coffee to the Removable Brew Basket. Do not fill above the MAX fill line.
Close Brew Basket Lid. Place Brew Basket in Funnel.
Close the Lid and snap it in place to latch ch Lid closed.
Use the Cup Rest for a cup/mug, or remove the Cup Rest for a travel mug.
Press desired cup size button: (8 oz./237 mL), (10 oz./296 mL), (12 oz./355 mL), or (14 oz./414 mL). The desired cup size button will illuminate when coffee is brewing.
Coffee Maker will shut off automatically when brewing is complete.
The removable Brew Basket should be rinsed after every use.
NOTE: The Fillheer Light and selected cup size light are flashing, refill the Water Reservoir, then press the flashing cup size button to finish brewing.

Care and Cleaning

WARNING Electrical Shock Hazard.

Do not immerse the cord, plug, or coffee maker in any liquid.

WARNING Burn Hazard.

Failure to allow the coffee maker to cool down may cause hot water or coffee to spray from the piercing needle. Use caution when cleaning.

CAUTION Cut Hazard.

The removable pod holder has a sharp needThe piercingcing needle on the underside of the lid also is sharp. Use caution when handling.

General Cleaning

Unplug and allow to cool.
Hand wash all removable parts in hot, soapy water. Rinse and dry or wash them in the top rack of the dishwasher. DO NOT use the “SANITIZE” setting when washing in the dishwasher. SANITIZE cycle temperatures could damage your product.
Wipe the outside of the Coffee Maker with a soft, damp cloth.

Clogged Needle

Unplug and allow to cool.
Remove the Removable Needle Holder in the Lid by turning counterclockwise from the locked iconto unlocked icon .
Bend a small paper clip. Insert the tip of the paper clip through the open hole of the Piercing Needle and up into the shaft of the Piercing le to ensure grounds have been removed.
To replace the Removable Needle Holder, insert the ert tab between the lock icon and unlock iconand turn clockwise to lock.

Routine Cleaning

All coffee makers should be cleaned at least once a month (once a week for areas with hard water).

Remove the Water Reservoir and discard the water. Add 1 1/2 cups (355 mL) of plain white vinegar to the Reservoir and return the Reservoir to its place.
Plug into an outlet.
Place a 15 oz. (444 mL) or larger cup or travel mug on Cup Rest to catch vinegar.
Press (10 oz./296 mL) cup size button. When vinegar starts dispensing, press cup-sizesize button again to stop brewing and althe low vinegar to clean. After 30 minutes, press the cup-size button and allow it to finish ish brew cycle. Empty Reservoir and fill with cold water; run 2-3 additional cycles with water only. The unit is cleaned and ready to brew coffee.
Unplug.

Troubleshooting

The coffee Maker will not brew/dispense coffee.

Piercing Needle may be clogged. Always remove the Removable Needle Holder. Clean Piercing Needle in Lid of Coffee Maker as shown on page 8.
Mineral deposits have formed. Clean the Coffee Maker following the directions in the Care and Cleaning section as shown on page 8.
Too little water. Need 16 oz. (473 mL) or more.

Coffee tastes bad.

Too much water was added or too much or too little ground coffee was addChangeathe nge the ratio of water to coffee grounds or use less water with coffee pods.
Poor coffee quality and freshness.
Poor water quality. Use filtered or bottled water.
Soft water causes poor coffee extraction, which leads to poor-tasting coffee. Use filtered, spring, or bottled water.

Coffee sediment in the cup.

Try a coarser grind of coffee, or add a #1 paper cone coffee filter to Removable Brew Basket. Make sure the hinged Lid is closed on the Removable Brew Basket.

Water is on a counter under the unit.

Overfilled Water Reservoir. Do not add more than 50 oz. (1.48 L) of water.

Coffee overflows from travel mug or regular mug.

Press any cup-size button to manually stop the brew cycle. Do not use a travel mug or regular mug since it will be very hot. Let the mug cool before emptying. Press the desired cup size button to start a new brewing cycle.

Lights flashing:

(14 oz./414 mL) and (iced coffee) buttons are flashing: The needle is clogged. Remove the Removable Needle Holder and follow the “Clogged Needle” instructions on page 8.
All cup size and (iced coffee) buttflashhing 3 times: The Coffee Maker Lid is not closed properly. The lid down to locks into place.
Refthe ill Water Light selected brew size light flashing: Refill the Water Reservoir, then press the flashing cup size button to finish brewing.

Coffee overflows from the Brew Basket.

Rinse the funnel with the basket removed to clean out sugar from the cocoa brew.
Use a Removable Brew Basket with Lid for ground coffee.
Use a lesser amount of ground coffee. 3 tablespoons (15 g) is the maximum amount of grounds to brew.
When using whole-bean coffee, a standard automatic drip coffee grind will yield the best results. Be careful not to overgrind, since very finely ground coffee can cause overflow.
Do not use soft water. Use filtered, spring, or bottled water. coffeefeee pod bursts.

There is variability in the pod manufacturing process, which causes some types of pods to be weaker at the seat msthe so the foil seal fails. Try a different brand.
If you are using softened water or live in an area where your tap water is naturally soft, this can cause coffee pod issues and filter basket overflows. Use filtered, spring, or bottled water.

Iced Coffee tastes weak.

Add fewer ice cubes to the cup or travel mug.
Use a bolder-flavored ground coffee.
Use a bolder flavored pod.

Limited Warranty

This warranty applies to products purchased and used in the U.S. and Canada. This is the only express warranty for this product and is in lieu of any other warranty or condition.

This product is warranted to be free from defects in material and workmanship for five (5) years from the date of original purchase in Canada and one (1) year from the date of original purchase in the U.S. During this period, your exclusive remedy is repair or replacement of this product or any component found to be defective, at our option; however, you are responsible for all costs associated with returning the product to us and our returning a product or component under this warranty to you. If the product or component is no longer available, we will replace it with a similar one of equal or greater value.

This warranty does not cover glass, filters, wear from normal use, use not in conformity with the printed directions, or damage to the product resulting from accident, alteration, abuse, or misuse. This warranty extends only to the original consumer purchaser or gift recipient. Keep the original sales receipt, as proof of purchase is required to make a warranty claim. This warranty is void if the product is used for other than single-family household use or subjected to any voltage and waveform other than as specified on the rating label (e.g., 120V ~ 60 Hz).

We exclude all claims for special, incidental, and consequential damages caused by breach of express or implied warranty. All liability is limited to the amount of the purchase price. Every implied warranty, including any statutory warranty or condition of merchantability or fitness for a particular purpose, is disclaimed except to the extent prohibited by law, in which case such warranty or condition is limited to the duration of this written warranty. This warranty gives you specific legal rights. You may have other legal rights that vary depending on where you live. Some states or provinces do not allow limitations on implied warranties or special, incidental, or consequential damages, so the foregoing limitations may not apply to you.

To make a warranty claim, do not return this appliance to the store. Please write Hamilton Beach Brands, Inc., Customer Service Department, 4421 Waterfront Dr., Glen Allen, VA 23060, or visit hamiltonbeach.com/customer-service in the U.S. or hamiltonbeach.ca/customer-service in Canada. For faster service, locate the model, type, and series numbers on your appliance.

For more manuals by Hamilton Beach, visit ManualsLibraryy

Hamilton Beach Gen 4 FlexBrew Single-Serve Coffee Maker Manual

Hamilton Beach Gen 4 FlexBrew Single-Serve Coffee Maker