Getinge Clean Manual Plus Detergent
Instructions for use
- Do not use in automatic washers
- Check materials compatibility before use
Manual process: Dose 2-20 ml of Manual Plus per liter of warm water (25-45°C).
- Stir well.
- Submerge instruments for 2-10 min.
- Brush if necessary.
Ultrasonic process: Dose 2-20 ml of Manual Plus per liter of warm water (45-60°C).
- Run ultrasonic bath for 2-10 min.
- Thoroughly rinse instruments prior to disinfection.
- Discard solution at least daily or after every 7-10 cycles.
The chart is only a guide
Information on the reprocessing of medical devices from the manufacturer according to EN ISO 17664 must always be followed.
M in the diagram means: Always refer to instrument manufacturer’s guidelines.
Product information
- Stabilized multi-enzyme formulation with powerful cleaning and sanitizing action
- Actively sanitizes cleaning bath and maintains hygienic conditions up to 8 hours
- Rapidly digests proteins, lipids, carbohydrates and biofilms
- Non-corrosive, neutral pH, effective in hard and soft water
- Fully biodegradable
Instructions for use
- Remove gross contamination from instruments.
- Measure the volume of the bath.
- Fill the bath with warm to hot water. 25-45°C preferred for manual cleaning and 45-60°C for ultrasonic baths.
- From the tables below determine the concentration of Getinge Clean Manual Plus required for the cleaning conditions applicable and add the required volume of the detergent to the pre- filled bath.
Manual cleaning
| Soiling level | Water quality | Dos age | Soak time at 45 C | Soak time at 25 C |
| Low | Good | 2 mL/L | 3 min | 5 min |
| Poor | 5 mL/L | 4 min | 7 min | |
| Moderate | Good | 5 mL/L | 5 min | 8 min |
| Poor | 10 mL/L | 7 min | 10 min | |
| High | Good | 10 mL/L | 7 min | 12 min |
| Poor | 20 mL/L | 10 min | 20 min |
Ultrasonic bath cleaning
| Soiling level | Water quality | Dos age | Contact time at 50 C | Contact time at 25 C |
| Low | Good | 2 mL/L | 1 min | 2 min |
| Poor | 6 mL/L | 1.5 min | 3 min | |
| Moderate | Good | 6 mL/L | 1 min | 2 min |
| Poor | 12 mL/L | 2 min | 4 min | |
| High | Good | 15 mL/L | 3 min | 5 min |
| Poor | 20 mL/L | 4 min | 6 min |
For more manuals by Getinge visit, ManualsLibraryy